Short communication: Teat-end shape and udder-level milking characteristics and their associations with machine milking-induced changes in teat tissue condition

Machine milking-induced changes in teat tissue condition, such as congestion and edema, have been associated with teat canal openness, penetrability, and thus susceptibility to new intramammary infections and diminished animal well-being. The primary objective of this study was to investigate the association of teat-end shape and machine milking-induced short-term changes in teat tissue condition. Our secondary objective was to study the association of udder-level milking characteristics and short-term changes. Data from 125 Holstein cows were analyzed in a longitudinal prospective cohort study. Cows were housed in freestall pens with sand bedding, fed a total mixed ration, and milked 3 times per day. Teat-end shape was classified into 3 categories: pointed, flat, and round. Udder-level milking characteristics were obtained from electronic on-farm milk meters. Short-term changes in teat tissue condition after machine milking were assessed visually. Multivariable generalized mixed model analysis showed an association between teat-end shape and short-term changes. Compared with teats with round teat-end shape, the odds ratio (95% confidence interval) for short-term changes was 1.68 (0.53-5.31) and 0.03 (0.004-0.19) in teats with pointed and flat teat-end shape, respectively. There was an association between milking characteristics and short-term changes such that higher milk flow rate during the first 15 s of milking decreased the likelihood of short-term changes. The adjusted probability of short-term changes for a milking observation of a mid-lactation cow and an average first 15-s milk flow rate of 0.5 and 1.5 kg/min was 53.0% (42.8-63.8) and 32.9% (15.2-57.3), respectively. Our results suggest that teat-end shape may be one of the risk factors that contribute to machine milking-induced short-term changes. Milking characteristics (e.g., first 15-s milk flow rate) may have the potential as a measure to indirectly monitor teat tissue changes associated with machine milking on a daily basis, though further research is needed to validate this hypothesis and to establish thresholds that could serve as on-farm guidelines.