• We are sorry, but NCBI web applications do not support your browser and may not function properly. More information
Logo of oenvmedOccupational and Environmental MedicineCurrent TOCInstructions for authors
Occup Environ Med. Oct 2001; 58(10): 649–655.
PMCID: PMC1740047

Experimental exposure to propylene glycol mist in aviation emergency training: acute ocular and respiratory effects

Abstract

OBJECTIVES—Propylene glycol (PG) (1-2 propanediol; CAS No 57-55-6) is a low toxicity compound widely used as a food additive, in pharmaceutical preparations, in cosmetics, and in the workplace—for example, water based paints, de-icing fluids, and cooling liquids. Exposure to PG mist may occur from smoke generators in discotheques, theatres, and aviation emergency training. Propylene glycol may cause contact allergy, but there is sparse information on health effects from occupational exposure to PG.
METHODS—Non-asthmatic volunteers (n=27) were exposed in an aircraft simulator to PG mist over 1 minute, during realistic training conditions. Geometric mean concentration of PG was 309 mg/m3 (range 176-851 mg/m3), with the highest concentrations in the afternoon. The medical investigation was performed both before and after the exposure (within 15 minutes). It included an estimate of tear film stability break up time, nasal patency by acoustic rhinometry, dynamic spirometry, and a doctor's administered questionnaire on symptoms.
RESULTS—After exposure to PG mist for 1 minute tear film stability decreased, ocular and throat symptoms increased, forced expiratory volume in 1 second/forced vital capacity (FEV1/FVC) was slightly reduced, and self rated severity of dyspnoea was slightly increased. No effect was found for nasal patency, vital capacity (VC), FVC, nasal symptoms, dermal symptoms, smell of solvent, or any systemic symptoms. Those exposed to the higher concentrations in the afternoon had a more pronounced increase of throat symptoms, and a more pronounced decrease of tear film stability. In four subjects who reported development of irritative cough during exposure to PG, FEV1 was decreased by 5%, but FEV1 was unchanged among those who did not develop a cough. Those who developed a cough also had an increased perception of mild dyspnoea.
CONCLUSION—Short exposure to PG mist from artificial smoke generators may cause acute ocular and upper airway irritation in non-asthmatic subjects. A few may also react with cough and slight airway obstruction.


Keywords: acoustic rhinometry; aviation medicine; propylene glycol; respiratory symptoms; tear film stability break up time

Full Text

The Full Text of this article is available as a PDF (146K).

Selected References

These references are in PubMed. This may not be the complete list of references from this article.
  • Glover ML, Reed MD. Propylene glycol: the safe diluent that continues to cause harm. Pharmacotherapy. 1996 Jul-Aug;16(4):690–693. [PubMed]
  • Gonzalo MA, de Argila D, García JM, Alvarado MI. Allergic contact dermatitis to propylene glycol. Allergy. 1999 Jan;54(1):82–83. [PubMed]
  • Funk JO, Maibach HI. Propylene glycol dermatitis: re-evaluation of an old problem. Contact Dermatitis. 1994 Oct;31(4):236–241. [PubMed]
  • Fisher AA. Systemic contact dermatitis caused by ingestion of certain foods in propylene glycol-sensitive patients. Am J Contact Dermat. 1996 Dec;7(4):259–259. [PubMed]
  • Skaare A, Kjaerheim V, Barkvoll P, Rølla G. Skin reactions and irritation potential of four commercial toothpastes. Acta Odontol Scand. 1997 Apr;55(2):133–136. [PubMed]
  • Meltzer EO, Orgel HA, Bush RK, Haltom JR, Metzger WJ, Moss BA, Mitchell DQ, Ballas ZK, Seltzer JM, Shapiro GG, et al. Evaluation of symptom relief, nasal airflow, nasal cytology, and acceptability of two formulations of flunisolide nasal spray in patients with perennial allergic rhinitis. Ann Allergy. 1990 Jun;64(6):536–540. [PubMed]
  • Greenbaum J, Leznoff A, Schulz J, Mazza J, Tobe A, Miller D. Comparative tolerability of two formulations of Rhinalar (flunisolide) nasal spray in patients with seasonal allergic rhinitis. Ann Allergy. 1988 Oct;61(4):305–310. [PubMed]
  • Goldsmith LA. Propylene glycol. Int J Dermatol. 1978 Nov;17(9):703–705. [PubMed]
  • Peleg O, Bar-Oz B, Arad I. Coma in a premature infant associated with the transdermal absorption of propylene glycol. Acta Paediatr. 1998 Nov;87(11):1195–1196. [PubMed]
  • Demey HE, Daelemans RA, Verpooten GA, De Broe ME, Van Campenhout CM, Lakiere FV, Schepens PJ, Bossaert LL. Propylene glycol-induced side effects during intravenous nitroglycerin therapy. Intensive Care Med. 1988;14(3):221–226. [PubMed]
  • Yorgin PD, Theodorou AA, Al-Uzri A, Davenport K, Boyer-Hassen LV, Johnson MI. Propylene glycol-induced proximal renal tubular cell injury. Am J Kidney Dis. 1997 Jul;30(1):134–139. [PubMed]
  • Casazza JP, Song BJ, Veech RL. Short chain diol metabolism in human disease states. Trends Biochem Sci. 1990 Jan;15(1):26–30. [PubMed]
  • Xu D, Dhillon AS, Abelmann A, Croft K, Peters TJ, Palmer TN. Alcohol-related diols cause acute insulin resistance in vivo. Metabolism. 1998 Oct;47(10):1180–1186. [PubMed]
  • Chang JC, Sparks LE, Guo Z, Fortmann R. Evaluation of sink effects on VOCs from a latex paint. J Air Waste Manag Assoc. 1998 Oct;48(10):953–958. [PubMed]
  • Gérin M, Patrice S, Bégin D, Goldberg MS, Vyskocil A, Adib G, Drolet D, Viau C. A study of ethylene glycol exposure and kidney function of aircraft de-icing workers. Int Arch Occup Environ Health. 1997;69(4):255–265. [PubMed]
  • Laitinen J, Liesivuori J, Savolainen H. Exposure to glycols and their renal effects in motor servicing workers. Occup Med (Lond) 1995 Oct;45(5):259–262. [PubMed]
  • Spreux A, Boyer A, Baldin B, Chichmanian RM. Toux ou crise d'asthme déclenchés par le propylèneglycol. Therapie. 1996 Sep-Oct;51(5):561–562. [PubMed]
  • Wyon NM, Wyon DP. Measurement of acute response to draught in the eye. Acta Ophthalmol (Copenh) 1987 Aug;65(4):385–392. [PubMed]
  • Wieslander G, Norbäck D, Nordström K, Wålinder R, Venge P. Nasal and ocular symptoms, tear film stability and biomarkers in nasal lavage, in relation to building-dampness and building design in hospitals. Int Arch Occup Environ Health. 1999 Oct;72(7):451–461. [PubMed]
  • Wålinder R, Norbäck D, Wieslander G, Smedje G, Erwall C, Venge P. Nasal patency and lavage biomarkers in relation to settled dust and cleaning routines in schools. Scand J Work Environ Health. 1999 Apr;25(2):137–143. [PubMed]
  • Wieslander G, Lindgren T, Norbäck D, Venge P. Changes in the ocular and nasal signs and symptoms of aircrews in relation to the ban on smoking on intercontinental flights. Scand J Work Environ Health. 2000 Dec;26(6):514–522. [PubMed]
  • Nihlén A, Wâlinder R, Löf A, Johanson G. Experimental exposure to methyl tertiary-butyl ether. II. Acute effects in humans. Toxicol Appl Pharmacol. 1998 Feb;148(2):281–287. [PubMed]
  • Andersson K, Hallgren C, Levin JO, Nilsson CA. Chemosorption sampling and analysis of formaldehyde in air. Influence on recovery during the simultaneous sampling of formaldehyde, phenol, furfural and furfuryl alcohol. Scand J Work Environ Health. 1981 Dec;7(4):282–289. [PubMed]
  • Norbäck D, Björnsson E, Janson C, Widström J, Boman G. Asthmatic symptoms and volatile organic compounds, formaldehyde, and carbon dioxide in dwellings. Occup Environ Med. 1995 Jun;52(6):388–395. [PMC free article] [PubMed]
  • Suber RL, Deskin R, Nikiforov I, Fouillet X, Coggins CR. Subchronic nose-only inhalation study of propylene glycol in Sprague-Dawley rats. Food Chem Toxicol. 1989 Sep;27(9):573–583. [PubMed]
  • Wahlberg JE. Erythema-inducing effects of solvents following epicutaneous administration to man--studied by laser Doppler flowmetry. Scand J Work Environ Health. 1984 Jun;10(3):159–162. [PubMed]
  • Beach JR, Raven J, Ingram C, Bailey M, Johns D, Walters EH, Abramson M. The effects on asthmatics of exposure to a conventional water-based and a volatile organic compound-free paint. Eur Respir J. 1997 Mar;10(3):563–566. [PubMed]
  • Millqvist E. Cough provocation with capsaicin is an objective way to test sensory hyperreactivity in patients with asthma-like symptoms. Allergy. 2000 Jun;55(6):546–550. [PubMed]
  • Millqvist E, Bengtsson U, Löwhagen O. Provocations with perfume in the eyes induce airway symptoms in patients with sensory hyperreactivity. Allergy. 1999 May;54(5):495–499. [PubMed]

Articles from Occupational and Environmental Medicine are provided here courtesy of BMJ Group

Formats:

Related citations in PubMed

See reviews...See all...

Cited by other articles in PMC

See all...

Links

  • Compound
    Compound
    PubChem Compound links
  • MedGen
    MedGen
    Related information in MedGen
  • PubMed
    PubMed
    PubMed citations for these articles
  • Substance
    Substance
    PubChem Substance links

Recent Activity

Your browsing activity is empty.

Activity recording is turned off.

Turn recording back on

See more...